Abstract
Biomass gasification technology is used as one of the energy sources due to its low effects on the environment and reducing pollution. This technology is able to produce gas with the highest content of hydrogen. Hydrogen can be used as a fuel and an important carrier of energy due to its stability and lack of negative effects on the environment. This study used wood sawdust as biomass to produce syngas and investigated the effect of adding carbon dioxide and methane gases to the Gibbs reactor. Aspen Plus software is used for steam gasification modelling. According to the results, the performed modelling is able to predict the experimental data well. When the carbon dioxide to biomass ratio (C/B) rises, the mass flow rates (MFR) of hydrogen and Methane fall while those of carbon dioxide and carbon monoxide increase. The decrease in hydrogen MFR with changes from C/B = 0 to C/B = 1 in modes a, b, c and d is equal to 17.51, 16.39, 29.57 and 24.84%, respectively. The mass flow of hydrogen increases as the Methane to biomass ratio (M/B) rises, whereas the MFR of carbon dioxide shows a declining pattern. As M/B increases from 0 to 1 in the Gibbs reactor for modes a, b, c and d, the hydrogen MFR increases by 265, 243, 297 and 305%, respectively.
REFERENCES
Aliabadi, M.A.F., Lakzian, E., Jahangiri, A., and Khazaei, I., Numerical investigation of effects polydispersed droplets on the erosion rate and condensation loss in the wet steam flow in the turbine blade cascade, Appl. Therm. Eng., 2020, vol. 164, article no. 114478. https://doi.org/10.1016/j.applthermaleng.2019.114478
Hosseinizadeh, S.E., Ghamati, E., Jahangiri, A., Majid-i, S., Khazaee, I., and Aliabadi, M.A.F., Reduction of water droplets effects in steam turbine blade using Multi-objective optimization of hot steam injection, Int. J. Therm. Sci., 2023, vol. 187, article no. 108155. https://doi.org/10.1016/j.ijthermalsci.2023.108155
Schandl, H., Hatfield-Dodds, S., Wiedmann, T., Geschke, A., Cai, Y., West, J., Newth, D., Baynes, T., Lenzen, M., and Owen, A., Decoupling global environmental pressure and economic growth: Scenarios for energy use, materials use and carbon emissions, J. Cleaner Prod., 2016, vol. 132, pp. 45–56. https://doi.org/10.1016/j.jclepro.2015.06.100
Montoya, F.G., Aguilera, M.J., and Manzano-Agugliaro, F., Renewable energy production in Spain: A review, Renewable Sustainable Energy Rev., 2014, vol. 33, pp. 509–531. https://doi.org/10.1016/j.rser.2014.01.091
Chen, X., Li, C., Grätzel, M., Kostecki, R., and Mao, S.S., Nanomaterials for renewable energy production and storage, Chem. Soc. Rev., 2012, vol. 41, no. 23, pp. 7909–7937. https://doi.org/10.1039/C2CS35230C
Demirbas, A., Political, economic and environmental impacts of biofuels: A review, Appl. Energy, 2009, vol. 86, suppl. 1, pp. S108–S117. https://doi.org/10.1016/j.apenergy.2009.04.036
Sharma, S., Agarwal, S., and Jain, A., Significance of hydrogen as economic and environmentally friendly fuel, Energies, 2021, vol. 14, no. 21, article no. 7389, pp. 1–28. https://doi.org/10.3390/en14217389
Fernández-Gonzalez, J.M., Grindlay, A.L., Serrano-Bernardo, F., Rodríguez-Rojas, M.I., and Zamorano, M., Economic and environmental review of Waste-to-Energy systems for municipal solid waste management in medium and small municipalities, Waste Manage., 2017, vol. 67, pp. 360–374. https://doi.org/10.1016/j.wasman.2017.05.003
Chang, A.C.C., Chang, H.-F., Lin, F.-J., Lin, K.H., and Chen, C.-H., Biomass gasification for hydrogen production, Int. J. Hydrogen Energy, 2011, vol. 36, no. 21, pp. 14252–14260. https://doi.org/10.1016/j.ijhydene.2011.05.105
Salam, M.A., Ahmed, K., Akter, N., Hossain, T., and Abdullah, B., A review of hydrogen production via biomass gasification and its prospect in Bangladesh, Int. J. Hydrogen Energy, 2018, vol. 43, no. 32, pp. 14944–14973. https://doi.org/10.1016/j.ijhydene.2018.06.043
Luo, S., Xiao, B., Hu, Z., Liu, S., Guo, X., and He, M., Hydrogen-rich gas from catalytic steam gasification of biomass in a fixed bed reactor: Influence of temperature and steam on gasification performance, Int. J. Hydrogen Energy, 2009, vol. 34, no. 5, pp. 2191–2194. https://doi.org/10.1016/j.ijhydene.2008.12.075
Loha, C., Chatterjee, P.K., and Chattopadhyay, H., Performance of fluidized bed steam gasification of biomass–Modelling and experiment, Energy Convers. Manage., vol. 52, no. 3, pp. 1583–1588. https://doi.org/10.1016/j.enconman.2010.11.003
Hernández, J.J., Ballesteros, R., and Aranda, G., Characterisation of tars from biomass gasification: Effect of the operating conditions, Energy. 2013, vol. 50, pp. 333–342. https://doi.org/10.1016/j.energy.2012.12.005
Jiang, L., Hu, S., Wang, Y., Su, S., Sun, L., Xu, B., He, L., and Xiang, J., Catalytic effects of inherent alkali and alkaline earth metallic species on steam gasification of biomass, Int. J. Hydrogen Energy, 2015, vol. 40, no. 45, pp. 15460–15469. https://doi.org/10.1016/j.ijhydene.2015.08.111
Cheng, Y., Thow, Z., and Wang, C.-H., Biomass gasification with CO2 in a fluidized bed, Powder Technol., 2016, vol. 296, pp. 87–101. https://doi.org/10.1016/j.powtec.2014.12.041
Shayan, E., Zare, V., and Mirzaee, I., Hydrogen production from biomass gasification; a theoretical comparison of using different gasification agents, Energy Convers. Manage., 2018, vol. 159, pp. 30–41. https://doi.org/10.1016/j.enconman.2017.12.096
Yang, S., Fan, F., Wei, Y., Hu, J., Wang, H., and Wu, S., Three-dimensional MP-PIC simulation of the steam gasification of biomass in a spouted bed gasifier, Energy Convers. Manage., 2020, vol. 210, article no. 112689. https://doi.org/10.1016/j.enconman.2020.112689
Zhang, Z., Delcroix, B., Rezazgui, O., and Mangin, P., Simulation and techno-economic assessment of bio-methanol production from pine biomass, biochar and pyrolysis oil, Sustainable Energy Technol. Assess., 2021, vol. 44, article no. 101002. https://doi.org/10.1016/j.seta.2021.101002
Prestipino, M., Piccolo, A., Polito, M.F., and Galvagno, A., Combined bio-hydrogen, heat, and power production based on residual biomass gasification: Energy, exergy, and renewability assessment of an alternative process configuration, Energies, 2022, vol. 15, no. 15, article no. 5524, pp. 1–17. https://doi.org/10.3390/en15155524
Chuayboon, S. and Abanades, S., Continuous solar-driven gasification of oil palm agricultural bio waste for high-quality syngas production, Waste Manage., 2022, vol. 154, pp. 303–311. https://doi.org/10.1016/j.wasman.2022.10.015
Pati, S., De, S., and Chowdhury, R., Exploring the hybrid route of bio-ethanol production via biomass co-gasification and syngas fermentation from wheat straw and sugarcane bagasse: Model development and multi-objective optimization, J. Cleaner Prod., 2023, vol. 395, article no. 136441. https://doi.org/10.1016/j.jclepro.2023.136441
Verma, S., Dregulo, A.M., Kumar, V., Bhargava, P.C., Khan, N., Singh, A., Sun, X., Sindhu, R., Binod, P., Zhang, Z., Pandey, A., and Awasthi, M.K., Reaction engineering during biomass gasification and conversion to energy, Energy. 2023, vol. 266, article no. 126458. https://doi.org/10.1016/j.energy.2022.126458
Vikram, S., Rosha, P., Kumar, S., and Mahajani, S., Thermodynamic analysis and parametric optimization of steam-CO2 based biomass gasification system using Aspen PLUS, Energy, 2022, vol. 241, article no. 122854. https://doi.org/10.1016/j.energy.2021.122854
Fremaux, S., Beheshti, S.-M., Ghassemi, H, and Shahsavan-Markadeh, R., An experimental study on hydrogen-rich gas production via steam gasification of biomass in a research-scale fluidized bed, Energy Convers. Manage., 2015, vol. 91, pp. 427–432. https://doi.org/10.1016/j.enconman.2014.12.048
Funding
This work was supported by ongoing institutional funding. No additional grants to carry out or direct this particular research were obtained.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
As author of this work, I declare that I have no conflicts of interest.
Additional information
Publisher’s Note.
Pleiades Publishing remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Bingxin Chen Effects of CO2 and CH2 Adding on Steam Gasification of Biomass Renewable Energy for Syngas Production Considering Parametric Investigation. Theor Found Chem Eng 57 (Suppl 1), S110–S120 (2023). https://doi.org/10.1134/S0040579523070035
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S0040579523070035