Abstract
This study determined the optimal ultraviolet (UV)-B dose of major vegetable seedlings in a plant factory with artificial light for labor saving. Four vegetable seedlings, cucumber, watermelon, tomato, and pepper, were used as test crops. UV-B irradiation was conducted at four different UV-B doses of 1.08, 2.16, 3.24, and 4.32 kJ·m−2 d−1 for 3 h a day for 3 days after graft-take and temporary planting of fruit vegetable seedlings. After UV-B irradiation, seedlings were moved to a greenhouse and exposed to ultraviolet rays of sunlight; growth was observed; and chlorophyll fluorescence was measured. When subjected to UV-B irradiation, minimal changes in external traits of fruit vegetable seedlings were observed at doses below 2.16 kJ·m−2·d−1, while at higher intensities, issues such as chlorosis emerged. When UV-B was irradiated at 4.32 kJ·m−2·d−1, cucumber exhibited a decrease in hypocotyl length by 6.4 cm, and watermelon by 1.7 cm compared with the control. Additionally, cucumber and watermelon both showed a decrease in leaf area by 75.6 cm2 and 49.8 cm2, respectively, indicating a tendency of growth inhibition. For tomatoes and peppers, when UV-B was irradiated at 1.08 kJ·m−2·d−1, they exhibited an improvement in compactness by 5 and 2.5 mg·cm−1, respectively, compared with the control. Chlorophyll fluorescence parameters indicated a positive correlation between ABS/RC and DIO/RC with increasing UV-B doses, while FV/FM and PIABS showed a negative correlation. Using UV-B during the seedling acclimation period, seedlings can adapt to external UV radiation, thereby suppressing excessive growth and promoting the production of robust seedlings. Moreover, the utilization of UV-B within a plant factory allows for conducting the acclimation process within the facility, reducing the need for seedlings to be transported to conventional nurseries and offering potential benefits in terms of operational efficiency.
References
Alemu ST (2020) Photosynthesis limiting stresses under climate change scenarios and role of chlorophyll fluorescence: a review article. Cogent Food Agric 6:1785136
An S, Hwang H, Chun C, Jang Y, Lee HJ, Wi SH, Yeo K-H, Yu I-h, Kwack Y (2021) Evaluation of air temperature, photoperiod and light intensity conditions to produce cucumber scions and rootstocks in a plant factory with artificial lighting. Horticulturae 7:102
Anne S, Lim JH (2021) Variability of chrysanthemum cultivars induced by gamma irradiation. Hortic Sci Technol 39:660–672
Bertram L, Lercari B (2000) Evidence against the involvement of phytochrome in UVB-induced inhibition of stem growth in green tomato plants. Photosynth Res 64:107–117
Castro FA, Campostrini E, Torres Netto A, Viana LH (2011) Relationship between photochemical efficiency (JIP-test parameters) and portable chlorophyll meter readings in papaya plants. Braz J Plant Physiol 23:295–304
Castronuovo D, Sofo A, Lovelli S, Candido V, Scopa A (2017) Effects of UV-C radiation on common dandelion and purple coneflower: first results. Int J Plant Biol 8:7255
Choi D-S, Nguyen TKL, Oh M-M (2022a) Growth and biochemical responses of kale to supplementary irradiation with different peak wavelengths of UV-A light-emitting diodes. Hortic Environ Biotechnol 63:65–76
Choi J, Kim J, Yoon HI, Son JE (2022b) Effect of far-red and UV-B light on the growth and ginsenoside content of ginseng (Panax ginseng CA Meyer) sprouts aeroponically grown in plant factories. Hortic Environ Biotechnol 63:77–87
Craver JK, Miller CT, Williams KA, Bello NM (2014) Ultraviolet radiation affects intumescence development in ornamental sweetpotato (Ipomoea batatas). HortScience 49:1277–1283
Del Corso G, Lercari B (1997) Use of UV radiation for control of height and conditioning of tomato transplants (Lycopersicon esculentum Mill.). Sci Hortic 71:27–34
Fehér B, Kozma-Bognár L, Kevei É, Hajdu A, Binkert M, Davis SJ, Schäfer E, Ulm R, Nagy F (2011) Functional interaction of the circadian clock and UV RESISTANCE LOCUS 8-controlled UV-B signaling pathways in Arabidopsis thaliana. Plant J 67:37–48
Govindjee (2004) Chlorophyll a fluorescence: a bit of basics and history. Chlorophyll a fluorescence: a signature of photosynthesis. Springer Netherlands 19:1–41
Hachiya Y, Sugeno W, Iwasaki Y (2017) Irradiation with UV-B fluorescent bulbs suppresses strawberry powdery mildew. In International Symposium on New Technologies for Environment Control, Energy-Saving and Crop Production in Greenhouse and Plant 1227, pp 549-554
Hayes S, Sharma A, Fraser DP, Trevisan M, Cragg-Barber CK, Tavridou E, Fankhauser C, Jenkins GI, Franklin KA (2017) UV-B perceived by the UVR8 photoreceptor inhibits plant thermomorphogenesis. Curr Biol 27:120–127
Hectors K, Jacques E, Prinsen E, Guisez Y, Verbelen J-P, Jansen MA, Vissenberg K (2010) UV radiation reduces epidermal cell expansion in leaves of Arabidopsis thaliana. J Exp Bot 61:4339–4349
Hideg É, Jansen MA, Strid Å (2013) UV-B exposure, ROS, and stress: Inseparable companions or loosely linked associates? Trends Plant Sci 18:107–115
Huché-Thélier L, Crespel L, Le Gourrierec J, Morel P, Sakr S, Leduc N (2016) Light signaling and plant responses to blue and UV radiations—Perspectives for applications in horticulture. Environ Exp Bot 121:22–38
Hwang H, An S, Pham MD, Cui M, Chun C (2020) The combined conditions of photoperiod, light intensity, and air temperature control the growth and development of tomato and red pepper seedlings in a closed transplant production system. Sustainability 12:9939
Jang DC, Xu C, Kim SH, Kim DH, Kim JK, Heo JY, Ngoc TV, Choi KY, Kim IS (2020) Effects of different application approaches with diniconazole on the inhibition of stem elongation and the stimulation of root development of cylindrical paper pot seedling. J Bio-Environ Control 29:365–372
Jang I, Do G, Hwang H, Suh S, Yu J, Jang I, Moon J, Chun C (2021) Morphological development and photosynthetic acclimation of Panax ginseng seedlings to irradiation by light-emitting diodes (LEDs). Hortic Environ Biotechnol 62:571–579
Jenkins GI (2009) Signal transduction in responses to UV-B radiation. Annu Rev Plant Biol 60:407–431
Jenkins GI (2017) Photomorphogenic responses to ultraviolet-B light. Plant Cell Environ 40:2544–2557
Jeong HW, Lee HR, Kim HM, Kim HM, Hwang HS, Hwang SJ (2020) Using light quality for growth control of cucumber seedlings in closed-type plant production system. Plants 9:639
Jo HG, Jeong HW, Lee HR, Kwon SM, Hwang HS, Hwang SJ (2021) Growth of tomato and pepper grafted plug seedlings under different shading condition during acclimatization after graft-taking. J Bio-Environ Control 30:10–18
Karabourniotis G, Liakopoulos G, Bresta P, Nikolopoulos D (2021) The optical properties of leaf structural elements and their contribution to photosynthetic performance and photoprotection. Plants 10:1455
Kim HC, Cho YH, Ku YG, Hwang SJ, Bae JH (2016) Growth characteristics of grafted tomato seedlings following treatment with various concentrations of diniconazole during the summer growth season. Hortic Sci Technol 34:249–256
Kim HG, Choi YH, Kim YH (2019) Graft-taking and growth characteristics of grafted cucumber (Cucumis sativus L.) seedlings as affected by light quality and blink cycle of LED modules. J Bio-Environ Control 28:143–149
Kimball B, Kobayashi K, Bindi M (2002) Responses of agricultural crops to free-air CO2 enrichment. Adv Agron 77:293–368
Kitaya Y, Niu G, Kozai T, Ohashi M (1998) Photosynthetic photon flux, photoperiod, and CO2 concentration affect growth and morphology of lettuce plug transplants. HortScience 33:988–991
Kozai T, Niu G (2020) Role of the plant factory with artificial lighting (PFAL) in urban areas. Plant Factory (Second Editon). Academic Press:7–34
Kubota C, Eguchi T, Kroggel M (2017) UV-B radiation dose requirement for suppressing intumescence injury on tomato plants. Sci Hortic 226:366–371
Kwon J-K, Lee J-H, Choi Y-H, Yu I-H, Hwang G-C (2003) Effects of UV-B and growth inhibitor on overgrowth retardation and growth and ield after planting in fruit-vegetable plug seedlings. J Bio-Environ Control 12:252–258
Lake JA, Field KJ, Davey MP, Beerling DJ, Lomax BH (2009) Metabolomic and physiological responses reveal multi-phasic acclimation of Arabidopsis thaliana to chronic UV radiation. Plant Cell Environ 32:1377–1389
Lee J-H, Shibata S, Goto E (2021) Time-course of changes in photosynthesis and secondary metabolites in canola (Brassica napus) under different UV-B irradiation levels in a plant factory with artificial light. Front Plant Sci 12:786555
Lee HJ, Moon YH, An S, Sim HS, Woo UJ, Hwang H, Kim SK (2023a) Determination of LEDs arrangement in a plant factory using a 3D ray-tracing simulation and evaluation on growth of Cucurbitaceae seedlings. Hortic Environ Biotechnol 64:765–774
Lee MH, Hahm S, Park J (2023b) Exogenous Gibberellin Application in tomato (Solanum lycopersicum) recovers growth inhibition caused by triazole overuse. Hortic Sci Technol 41:285–294
Lidon F, Ramalho J (2011) Impact of UV-B irradiation on photosynthetic performance and chloroplast membrane components in Oryza sativa L. J Photochem Photobiol b: Biol 104:457–466
Liu F, Chen H, Han R (2015) The effects of He-Ne laser and enhanced ultraviolet-B radiation on proliferating-cell nuclear antigen in wheat seedlings. Am J Plant Sci 6:1206
Liu X, Shi R, Gao M, He R, Li Y, Liu H (2022) Effects of LED light quality on the growth of pepper (Capsicum spp.) seedlings and the development after transplanting. Agronomy 12:2269
Liu Z, Yang P, Fadiji T, Li Z, Ni J (2023) Biomechanical response of the above-ground organs in tomato seedling at different age levels under wind-flow disturbance. Sci Hortic 312:111835
Melis A (1999) Photosystem-II damage and repair cycle in chloroplasts: What modulates the rate of photodamage in vivo? Trends Plant Sci 4:130–135
Meyer P, Van de Poel B, De Coninck B (2021) UV-B light and its application potential to reduce disease and pest incidence in crops. Hortic Res 8:194
Mosadegh H, Trivellini A, Ferrante A, Lucchesini M, Vernieri P, Mensuali A (2018) Applications of UV-B lighting to enhance phenolic accumulation of sweet basil. Sci Hortic 229:107–116
Mosadegh H, Trivellini A, Maggini R, Ferrante A, Incrocci L, Mensuali A (2021) In-vivo in-vitro screening of Ocimum basilicum L. ecotypes with differential UV-B radiation sensitivity. Horticulturae 7:101
Myung J, Pham MD, Hwang H, Lee B, Lee H, Cui M, Shin J, Chun C (2023) UV-B supplementation to mitigate intumescence injury of tomato seedlings. Hortic Environ Biotechnol 64:917–926
Palma CFF, Castro-Alves V, Morales LO, Rosenqvist E, Ottosen C-O, Strid Å (2021) Spectral composition of light affects sensitivity to UV-B and photoinhibition in cucumber. Front Plant Sci 11:610011
Piccini C, Cai G, Dias MC, Romi M, Longo R, Cantini C (2020) UV-B radiation affects photosynthesis-related processes of two Italian Olea europaea (L.) varieties differently. Plants 9:1712
Qian M, Rosenqvist E, Flygare A-M, Kalbina I, Teng Y, Jansen MA, Strid Å (2020) UV-A light induces a robust and dwarfed phenotype in cucumber plants (Cucumis sativus L.) without affecting fruit yield. Sci Hortic 263:109110
Quist G, Chow W, Anderson J (1992) Photoinhibtion of photosynthesis represents a mechanism for the long-term regulation of photosystemll. Planta 186:450–460
Sallaku G, Sanden H, Babaj I, Kaciu S, Balliu A, Rewald B (2019) Specific nutrient absorption rates of transplanted cucumber seedlings are highly related to RGR and influenced by grafting method, AMF inoculation and salinity. Sci Hortic 243:177–188
Sangtarash M, Qaderi M, Chinnappa C, Reid D (2009) Differential sensitivity of canola (Brassica napus) seedlings to ultraviolet-B radiation, water stress and abscisic acid. Environ Exp Bot 66:212–219
Strasser RJ, Srivastava A, Tsimilli-Michael M (2000) The fluorescence transient as a tool to characterize and screen photosynthetic samples. Probing Photosynth: Mech Regul Adapt 25:445–483
Strasser BJ (1995) Measuring fast fluorescence transients to address environmental questions: the JIP test. Photosynthesis: from light to biosphere. pp. 977–980
Sullivan JH, Gitz DC, Peek MS, McElrone AJ (2003) Response of three eastern tree species to supplemental UV-B radiation: leaf chemistry and gas exchange. Agric for Meteorol 120:219–228
Suthaparan A, Stensvand A, Solhaug K, Torre S, Telfer K, Ruud A, Mortensen L, Gadoury D, Seem R et al (2014) Suppression of cucumber powdery mildew by supplemental UV-B radiation in greenhouses can be augmented or reduced by background radiation quality. Plant Dis 98:1349–1357
Toscano S, Trivellini A, Ferrante A, Romano D (2018) Physiological mechanisms for delaying the leaf yellowing of potted geranium plants. Sci Hortic 242:146–154
Tsukaya H (2005) Leaf shape: genetic controls and environmental factors. Int J Dev Biol 49:547–555
Yang H-C, Kim Y-H, Byun H-J, Choi I-L, Vu N-T, Kim D-H, Yoon H-S, Jang D-C (2023) Identification of appropriate light intensity and daytime temperature for cucumber (Cucumis sativus L.) seedlings in a plant factory with artificial lighting for use as grafting material. Sustainability 15:4481
Yin R, Ulm R (2017) How plants cope with UV-B: from perception to response. Curr Opin Plant Biol 37:42–48
Yu G, Li W, Yuan Z, Cui H, Lv C, Gao Z, Han B, Gong Y, Chen G (2013) The effects of enhanced UV-B radiation on photosynthetic and biochemical activities in super-high-yield hybrid rice Liangyoupeijiu at the reproductive stage. Photosynthetica 51:33–44
Zuk-Golaszewska K, Upadhyaya M, Golaszewski J (2003) The effect of UV-B radiation on plant growth and development. Plant Soil Environ 49:135–140
Zvezdanović J, Cvetić T, Veljović-Jovanović S, Marković D (2009) Chlorophyll bleaching by UV-irradiation in vitro and in situ: Absorption and fluorescence studies. Radiat Phys Chem 78:25–32
Acknowledgements
This work was supported by Innovative Human Resource Development for Local Intellectualization program through the Institute of Information & Communications Technology Planning & Evaluation(IITP) grant funded by the Korea government(MSIT)(IITP-2024-RS-2023-00260267).
Author information
Authors and Affiliations
Contributions
Conceptualization, HCY; methodology, DCJ; validation, HCY and YHK; formal analysis, HCY; investigation, SJH; resources, DCJ; writing-original draft preparation, HCY; writing-review and editing, YHB; visualization, SJH; supervision, YHK and YHB; project administration, HCY; funding acquisition, DCJ. All authors have read and agreed to the published version of the manuscript.
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no conflict of interest.
Ethical approval
This article does not contain any studies with human participants or animals performed by any of the authors.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Yang, H., Kim, Y., Bae, Y. et al. Acclimation and hardness enhancement through ultraviolet-B irradiation of fruit vegetable seedlings grown in a plant factory with artificial light. Hortic. Environ. Biotechnol. (2024). https://doi.org/10.1007/s13580-024-00605-7
Received:
Revised:
Accepted:
Published:
DOI: https://doi.org/10.1007/s13580-024-00605-7